Judged: 11 7 2 Reply » Report Abuse Judge it! mr2tall1808-07-2004, 02:26 PMOn our van the fusible links were on the driver side under the hood they ran along the fender . Judged: 1 Reply » Report Abuse Judge it! Good luck and let me know if that helped. http://camtronics.net/dodge-caravan/2000-dodge-caravan-cooling-fans-not-working.html
High is for when the a/c is on, or the transmison calls for high cooling ( why the trans is any ones guess) So there are 2 relays, low and high, Without a doubt the biggest lemon I have ever owned. Can't find anything on-line pertaining to location. If the economy doesn't change the credit card company may have to do a write-off on me because although i work hard, i don't make much and there now raising my
I still do not understand why they made a simple thing like a cooling fan so complicated. Finally took it to dealer, and they found the relay switch that turns on the fan was broken brunswick03-23-2006, 06:11 PMThank you for the heads-up. jpb5305-20-2008, 10:52 PMWhen you push the button on the A/C control head the PCM gets a signal that the A/C is requested on. Radiator fan would not run.
Thanks for the free ride! Spit casa0112-16-2004, 04:46 PMI do not remember where I left the receipt, but I just asked the guy @ the counter(bumper to bumper ) and he ordered me one. Has a 4 wire plug. Dodge Caravan Overheating Problems In desperation, I replaced the coolant temp sensor (about $30.) and wouldn't you know it, the fans started cutting in again exactly the way they're supposed to.
Have no idea where or what that is. Dodge Caravan Coolant Temperature Sensor Location Relays Prehaps?? I let the van run and it over heated again, thats when I went and checked everything out. a fantastic read At first I though the "BLOWER MOTOR" might be that, but it is for the AC fan, right?
After a good cool off, I took about 30 minutes to go through a series of trial and error tests like pulling fuses, jiggling wires, tapping the fans, etc and nothing Chrysler Town And Country Overheating Problems I believe the fan motor control relay is stuck in the closed position. Loading... you can also call a dodge dealer and ask them for the part numer or better yet go there and they will pull a pcture of the relay and its location
This sensor is about 60 bucks but usually is the cause of the problem. When the bottle overflows is because the coolent is too hot, it is boiling and then turns to steam and the presssure builds and wants to leave the system. 1999 Dodge Grand Caravan Overheating I tried to find one at the local junkyard and was told he wanted $200.00 for it. 2002 Dodge Caravan Coolant Temperature Sensor Location The transmission has a clunk in it sometimes.
FCA keeps switching quality chiefs, but problem... http://camtronics.net/dodge-caravan/1999-dodge-caravan-dashboard-not-working.html Dodge Grand Caravan Owner San Diego, CA #6 Nov 13, 2007 CURT wrote: MY MECHANIC IS CHARGING ME 265.00 TO REPLACE WHAT HE CALLS A BLOWER RELAY. 88.00 FOR THE PART Tim Flag inappropriateCOMMENT by Visitor, June 28, 2011Your welcome Tim I had same problem last year on a plymoth voy, Flag inappropriateSign in to replyQualified Local Dodge Shops Qualified Dodge Shops Working... 2005 Dodge Grand Caravan Radiator Diagram
i have left the van idleing for a very long time and the temp gauge never goes over half and the fans never come on and the van never overheats. Chrysler is archaic. It is screwed on the van chassi next to the bottom corner of the radiator and below the left head light (driver side). have a peek here if i disconnect the fan relay or the coolant temp sensor, i get a code, but if i hook them back up and clear the codes, i don't get anymore codes.
My Hayes book shows the 4 relays. Radiator Fans Not Coming On While in the Air Force I served a number of years in a flight test squadron working avionics on jets. Dealer just wants to sell me diagnostic time and then talks all the usual BS (flush the system; change the thermostat; etc.
Is that common?Find a ShopDodge Repair in Olympia, WADodge Repair in Covina, CADodge Repair in Hollywood, FLDodge Repair in Santa Barbara, CADodge Repair in Palo Alto, CADodge Repair in Eugene, ORQuestions›Dodge›Grand The Car Doctor 31,466 views 6:07 Chrysler Town & Country / Caravan - P0480 Cooling Fan trouble - Duration: 17:56. No Change. Dodge Parts It is really great to read other peoples experiences.
Related Content1999 Dodge Grand Caravan Repair and Maintenance1999 Dodge Grand Caravan Maintenance Schedule1999 Dodge Grand Caravan Problems(25)1999 Dodge Grand Caravan Repair Estimates1999 Dodge Grand Caravan Q&A(85)1999 Dodge Grand Caravan Recalls(3)1999 Dodge jpb5305-17-2008, 09:41 PMThink about it. Thanks again... http://camtronics.net/dodge-caravan/1999-dodge-caravan-dash-not-working.html So for know I am using a toggle switch for the fan.
Remove the wiring harness with a small hooked flat screwdriver under the (hidden) inside area of the locking tab. out of curiosity, by looking at the temp gauge, about when should the fans come on? If I put 12 volts on that yellow wire I get sparks. I pulled the connector off the relay by depressing the little unlocking lever (I don't know what it is called)on the connector...slips off easy...no need special tool but can be tricky.
oldskool funk 338,998 views 25:28 Changing the fan relay on a Dodge Caravan - Duration: 11:19. I turn on the a/c (which is out of freon, but the switch should still turn on the fans right?) and no fans. At that point the power train controll will either select low or high.