waldreps is offline Quick Reply waldreps View Public Profile Find More Posts by waldreps Remove Advertisements Sponsored Links Dodge Talk Forum Advertisement post #2 of 8 Old 01-07-2011, 05:17 But having already visited the same junk yard I had just the van in mind to get a replacement door from. If you have not yet registered, you can register here. Also feel your supply and return hoses to the heater core. have a peek here
And the idea of removing the entire dash was too overwhelming for a weekend project. And thanks for the extra info and pictures!I have a 2002 dodge Grand Caravan and my blend door is cracked need help fixing it. Yesterday 04:16 PM by dmcelhannon 24 Lighting Tech 101:... Next, if you have a test light, just check for power at the pigtail for the blower motor. https://www.ifixit.com/Answers/View/94848/fan+works+but+no+heat+comes+into+cabin.+Troubleshooting+ideas
I unplugged both plugs from the blower motor resister and probed all kinds of combinations of wires in the plugs but didn't find 12v power anywhere. Last edited by no_common_sense; 01-11-2011 at 12:50 AM. Please help! I 'carefully' removed the blend door from the heater box, with a tire iron I found in the van.
I didn't take a picture but I sealed it all up with duct tape when I was finished.
What epoxy/glue did you use? Was it the head gasket replacement that solved the problem? no_common_sense is offline Quick Reply no_common_sense View Public Profile Find More Posts by no_common_sense post #4 of 8 Old 01-09-2011, 07:57 PM Thread Starter waldreps Registered User Join Date: How To Replace Blend Door Actuator Dodge Caravan Thanks!
What we've done to avoid some headache is to remove the passenger side seat so you can lay down on the job. The shaft should only be able to make about a quarter of the circle if the shaft is still attached to the door, it might catch a bit but if it mini cooper s10-02-2009, 11:08 AMMy 2001 grand cara van 's ignition is sporatic, the heater control is not getting power therefore no heat and unable to control direction of air flow,
I turned the front fan to high and of course nothing happened.
Is the power button on? 2003 Dodge Caravan Blend Door Replacement I would agree the housing is hard to get off. Now I have heat in my van once again!!! waldreps is offline Quick Reply waldreps View Public Profile Find More Posts by waldreps post #8 of 8 Old 01-11-2011, 05:59 AM mfahey Registered User Join Date: Nov 2006
So cutting into the heater box would cost me nothing as the whole thing would be replaced if I couldn't fix it and had to go the "correct" route to have http://www.dodgetalk.com/forums/showthread.php?t=322013 If I turn the temp knob to cold and back to hot, sometimes I'll get heat back right away. 2005 Dodge Grand Caravan Heater Not Working It can only be 2 or 3 things . Dodge Caravan Climate Control Problems Yesterday 08:43 PM by Diode Dynamics 70 Dodge Charger LED...
As it turns out my climate control module was at fault for the blend door breaking. navigate here Since these are actuators and not servos they keep going until the power is killed.
Unless you're 5'1" and 95lbs, remove the driver side seat! But when I started out I was just hacking and hoping... They did give me a brand new car to drive while they were working on this and they aren't charging me anything. 2000 Dodge Caravan Blend Door Actuator
The gear on the actuator should only do about 30% of a rotation, mine was somewhere around 110%! So I left the junk yard only having to pay the 2 bucks it cost for admission to the yard.When I got home I put some white lithium grease on the I had no heat and the fix is to replace the whole heater box that contained the blend door... http://camtronics.net/dodge-caravan/2001-dodge-grand-caravan-sport-heater-not-working.html AOL E-MAIL USERS: Please click HERE for important info pertaining to your e-mail address.
Could that be the "blend door"? 2002 Chrysler Town And Country Heater Problems Thanks for any help. You'll need a 21mm deep well socket to do it.
I used a dremel and a hot knife to cut the plastic.
should be the looking for the mode door, not the zone door...
Thanks for reply. vipergg12-07-2005, 07:47 PMSorry for the delay in my response. Please include your USERNAME and the EMAIL YOU REGISTERED WITH to speed up your request. 2007 Dodge Grand Caravan Heater Not Working Hope my experience helps someone.
Fredge is offline Quick Reply Fredge View Public Profile Find More Posts by Fredge post #7 of 8 Old 01-11-2011, 01:19 AM Thread Starter waldreps Registered User Join Date: Can anybody rule this out for him. :2cents: xxguesswho12-18-2005, 01:29 PMOk, after another visit to the same dealership (which I'm stuck with because of the warranty) they finally figured out what vicky B33p3r12-05-2005, 10:46 PMA bad water pump would cause you to overheat. http://camtronics.net/dodge-caravan/97-dodge-caravan-heater-not-working.html This all seems to have started at the same time.
by funcky in cars Download 1 Steps Share Favorite I Made it! As I mentioned before I had been there earlier this summer trying to get a better look at the blend door in a 'broken' van with no success. Cold air is coming in all the vents, not just some of them. I dig at the same place as you, found the godamn trap and succesfully fixed it in heat mode.
Using some gorilla tape I taped the parts I had cut out of the heater box back over the hole. I'm thinking You are looking at the wrong actuator...? If you have verified the blower IS bad, there is one particular screw at the back of the motor housing that is very difficult to remove. wireman212-06-2005, 07:27 AM[had that happen on an Altima I had, it ended up being air caught in the cooling system.
Register Now In order to be able to use most of our features, you must first register. Stampede4.7 3G Dodge RAM - General Talk 8 06-22-2010 09:48 AM Heater not working 1999ram1500 2G Dodge RAM - General Talk 1 12-30-2006 07:13 PM Heater not working right???