Home > Fuel Gauge > 2002 Volvo S40 Fuel Gauge Not Working

2002 Volvo S40 Fuel Gauge Not Working

Contents

I have similar symptom but the orange low fuel light does NOT come on. +1. To remove the fuel lines you need to push in these two clips as seen in the next photo (one is red and other is black) and pull out the fuel Similar Topics Similar Topics Topic Replies Topic Starter Views Last Action One Rule For Consistent Gym Attendance 0 jonymama 3 Yesterday, 07:02 PMLast post by: jonymama Problem With Radio 1 Anyone else check L and R level with VIDA? http://camtronics.net/fuel-gauge/2001-volvo-s40-fuel-gauge-not-working.html

Just lift it up and out of the way. You now need to remove the black ring/plastic nut/top cover securing the fuel pump to the tank. Remove its fixing screws & remove it.No smoking/naked flames/sparks!Remove the “cage” from above the sender unit and disconnect the wiring connector from the fuel pump/sender unit then, with rags at the There is a procedure for checking voltage between pins on the CEM, but I do not have the wiring diagram for your car so I do not know the correct pins

Volvo S40 Fuel Gauge Fuse

Mods: IPD (Stage 2 ECU, Trak Spec F&R sways, 3" DP, HD-TCV, HD-coils, HD-endlinks, SS brake lines), HEICO (CATback, 18" Volution wheels), Phuz PhMIC, JRL resonator delete, RKelly CAI, PLX OLED eid=213784 or $66 here: http://www.tascafordparts.com Search for part #8683142Make sure you give them all the info about your car to ensure you get the correct part.Then either install it yourself or Short-circuit to ground Diagnostic trouble code (DTC) information CEM-4A38 Condition The central electronic module (CEM) continuously checks the signal from the sensor on the pump side which indicates the level in Please sign up or sign in and take part in the conversation with other Volvo owners and enthusiasts.

Unscrew the large plastic nut that secures the combined fuel pump/sender and pull it up (let it drain for a few seconds before taking it out all the way), Then simply I am hardly getting 200 miles per full tank and I am not riding it hard. If you have not received your password reset email please use the password reset function “forgot password”. Volvo V70 Fuel Gauge Not Working Reply Leave a Reply Cancel reply Your email address will not be published.

S40 / V40 '96-'04 General Forum for the Volvo S40 and V40 (Classic) Series from 1995-2004. We use cookies on this website. Hope this helps. __________________ 1987 Ford mustang LX Coupe 5.0 1995 Yellow T5-RM running 1996 850 turbo 1994 N/A 5-speed wagon Purple (daughters) #16 01-25-2006, 11:14 PM androide016 Garage https://www.cargurus.com/Cars/Discussion-t24582_ds538229 I tend to rely more on the "distance to empty" reading.

Give back to MVS Amazon purchase? Volvo S60 Fuel Sending Unit Loading... Airtex/ASC Performance Pumps 196,478 views 3:46 Fixing Gas Gauge on 95-2002 Ford - Duration: 4:10. I saw some images and wondered..

Volvo S40 Fuel Sender Unit

He wrote (in part): (BEGIN QUOTE): CEM-4A38 Fuel level sensor. try this Might be worth depressurizing the fuel system first (remove fuse #17 - fuel pump I believe - but do check!) then run the engine until she stalls. Volvo S40 Fuel Gauge Fuse Currently on the low end they read correctly, but it wont go to the high end. Volvo S60 Fuel Gauge Problem This happened once before, but after about 8 hours it was fine again.

Undo the four screws securing this top metal cover and remove it You will now see another metal cover which seems to offer some extra protection and hold the pump/fuel deposit http://camtronics.net/fuel-gauge/2002-f350-fuel-gauge-not-working.html On a 3 week old car? The S60 I am dropping the tank now (It's a California emissions car, damn their green-ness), and the S80 I have been all over. I am not sure if they use a float or a "fuel strip" to gauge the level. Volvo Xc90 Fuel Gauge Not Working

Transcript The interactive transcript could not be loaded. Problem on this car is that a final diagnosis will require a Volvo code reader, since it will log one or more CEM-4AXX and REM-4AXX codes when it detects a bad Ron 2006 V70R Black GT 377 awhp TME Exhaust, Girodisc 2 piece rotors IPD Sway bars, HD end links, Strut Brace, Poly engine mounts EST CAI, Silicone hose kits, SNABB intake, this contact form Forum owners such as us are finding that AOL, Yahoo and Plus.net are blocking a lot of email generated from forums.

However, I bought the car used last year, so I don't think the original warranty would apply to me (even if I wasn't over on the mileage). Volvo S80 Fuel Gauge Problems I put a post on here just before christmas where the fuel gauge went down to the red but it did not go back up, and some one told me it We use data about you for a number of purposes explained in the links below.

ScannerDanner 90,904 views 18:26 Gas Gauge Reads Too Low - Duration: 5:23.

The diagnostic trouble code (DTC) is stored if the central electronic module (CEM) registers a short-circuit to ground in the sensor. Sigh. 2006 Sonikap V70R MT. the rest is pretty much reversal of removal. Volvo S40 Fuel Gauge Calibration Had this happen on my old vauxhall calibra but that was after a fast an the furious style jump back in my teen boy racer days!!!

When the fuel warning light comes on, there will normally be at least 2 gallons of fuel left in the tank of most cars, sometimes more. I am pulling the unit again to make sure, but I was wondering if anyone else has encountered similar issues. Loading... navigate here I really hope I don't have to go through that whole "no fault go home" business...

I absolutely love the car. Dmonkey 65,918 views 14:39 Fuel Tank Level Sensor - Duration: 2:41. The time now is 07:24 AM. -- volvo37 Contact Us - Volvo Forums - Volvo Enthusiasts Forum - Archive - Advertising - Cookie Policy - Privacy Statement - Terms of Service I would bet that ohming out the sensor after the gauge drops will show extremely low resistance/a short.

After you have releived the pressure and removed the lines.You are supposed to use a special tool to loosen it. This float thing is an anomaly you are not alone on this problem 2 out of 2 people think this is helpful. The weird thing, like I said, is that once the fuel level falls below 1/4 tank, the gauge starts working properly again. The problem has now reoccurred.Is this something I can repair myself?

I am very much interested in experience of others: is this a software error or a physical, intermittently occuring short? I have made a detailed guide of how to remove the sender unit. Note that passwords are case-sensitive. The behavior just took a couple days off, the sender did not fix it.

ford, BMW, Audi, VW, Seat etc. However, I am puzzled by one thing. This website uses cookies to improve your experience. You will see the sending unit assembly.

Top vegasjetskier MVS Moderator Posts: 1844 Joined: Mon Dec 17, 2007 1:35 am Year and Model: 2010 Toyota Prius Location: Fernandina Bch, FL Formerly - Las Vegas, NV Re: 2006 S60 Could it be that is not reading correctly?, when I fill up the S40 I have to push in $17.00 of gas, while the 740 takes easy $ 24.00. [ This Amazon link helps MVSNot a forum member? The 1.9D, 1.9TD and 1.8 GDI S40 and V40 don't have the pump in the sender unit and instead use the high pressure pumps in the engine compartment.

Today 01:08 AM by T5Polestar 44 Hidden features of the... Loading...